Microsclerotia from Metarhizium robertsii: Production, ultrastructural analysis, robustness, and insecticidal activity.

Microsclerotia (MS) are considered one of the most promising propagules for use as active ingredients in biopesticides due to their tolerance to abiotic factors and ability to produce infective conidia for the control of pests. Therefore, the objective of this research was to establish the conditions required to induce the formation of microsclerotia in Metarhizium robertsii Mt004 and to study its development process, tolerance to abiotic factors and insecticidal activity of MS-derived conidia. M. robertsii started to form hyphal aggregates after 2 days and looked more compact after 8 days. MS were mature and pigmented after 20 days. The final yield was 2.0 × 103 MS/mL and MS size varied between 356.9 and 1348.4 µm. Ultrastructure analysis revealed that mature MS contained only a few live cells embedded in an extracellular matrix. Mature MS were more tolerance to UV-B radiation, heat and storage trials than conidia from Solid State Fermentation. MS-derived conidia were as virulent as conidia against Diatraea saccharalis larvae. These results showed that MS are promising propagules for the development of more persistent and efficient biopesticides for harsh environmental conditions. Our findings provide a baseline for production and a better understanding of microsclerotia development in M. robertsii strains.

Physicochemical characterisation of casings in relation to mushroom (Agaricus bisporus) cropping performance.

Peat-based casings have been used for button mushroom (Agaricus bisporus) cultivation for decades but there is environmental pressure to find sustainable alternatives. This work aimed to characterise the physicochemical properties of peat and peat-substituted casings and to determine their influence on mushroom cropping to enable alternatives to be identified. British milled peat and German wet-dug peat casings produced smaller mushrooms than Irish wet-dug peat casing although yield was unaffected. Substitution of milled or wet-dug peat casings with 25% v/v bark, green waste compost or spent mushroom casing, except Irish wet-dug peat casing with spent peat mushroom casing, caused reductions in mushroom yield and/or size. These poorer results of casings compared with Irish wet-dug peat casing corresponded with lower water retention volumes at matric potential (Ψm) -15 kPa but not after drainage from saturation or at -1 kPa. Air-filled porosity (17-22% v/v), compacted bulk density after drainage (670-800 g L-1) and electrical conductivity (0.30-0.54 mS cm-1) of casings were unrelated to their mushroom cropping performance. In-situ casing measurements with electronic tensiometers confirmed laboratory casing physical analysis: at the same casing Ψm, Irish wet-dug peat casing had a higher water content than German wet-dug peat casing and produced larger mushrooms for the same yield. Solid-state foam-based tensiometers were more robust than water-filled tensiometers but they did not detect the full decrease in casing Ψm during a flush of mushrooms. The results indicate that if sustainable materials are to replace wet-dug peat casing with the same mushroom yield and size quality performance, they should have equivalent water retention volumes at Ψm -15 kPa. Measurement of casing Ψm with electronic tensiometers to control mushroom crop irrigation should assist in this transition.

Metabolomic changes in culture media with varying passage numbers of pig muscle stem cell culture for cultured meat production.

Selecting the primary cells in an optimal state for cultured meat production is a crucial challenge in commercializing cultured meat. We investigated the metabolomic changes in culture media according to passage numbers for indirectly assessing the state of primary cells. Pig skeletal muscle stem cells (PSCs) harvested from the biceps femoris muscles of 7-d-old crossbred pigs (Landrace × Yorkshire × Duroc, LYD) were used for cell characterization. Fresh media (FM) and spent media (SM) of PSCs during passages 1 to 3 in vitro culture were prepared for metabolomics analysis. SM was collected on the third day of proliferation for each passage of PSCs. Cell characterization analysis revealed that the proliferation rate was highest at passage 2; however, a significant loss of expression of myogenic marker genes was observed at passage 3. Based on metabolomic profiles of culture media, FM and SM groups (SM1, SM2, and SM3) were clearly separated by partial least squares-discriminant analysis. A total of seven differentially abundant metabolites (DAMs) were identified from FM and SM for each passage, based on the following criteria: P < 0.05, fold change > 1.5 or < 0.66, and a variable importance in projection score > 1.5. All seven DAMs and their interconnected metabolites might be primarily used as substrates for energy production and most of them were relatively abundant in SM3. Among the seven DAMs, the three potential biomarkers (γ-glutamyl-L-leucine, cytosine, and ketoleucine), which showed significant changes exclusively in SM3, each had an area under the curve value of 1. Therefore, monitoring the levels of these key metabolites in culture media could serve as a quality control measure for cultured meat production by enabling the indirect detection of suboptimal PSCs based on their proliferation ability.

Biochemical and functional characterization of heat-inactivated coelomic fluid from earthworms as a potential alternative for fetal bovine serum in animal cell culture.

Fetal bovine serum (FBS) plays a pivotal role in animal cell culture. Due to ethical and scientific issues, searching for an alternative, comprising the three R's (Refinement, Reduction and Replacement) gained global attention. In this context, we have identified the heat inactivated coelomic fluid (HI-CF) of the earthworm, Perionyx excavatus as a potential alternative for FBS. Briefly, we formulated HI-CF (f-HICF) containing serum free medium which can aid the growth, attachment, and proliferation of adherent cells, similar to FBS. In this study, we investigated the biochemical characterization, sterility, stability, formulation, and functional analysis of HI-CF as a supplement in culturing animal cells. Notably, vitamins, micronutrients, proteins, lipids, and trace elements are identified and compared with FBS for effective normalization of the serum free media. HI-CF is tested to be devoid of endotoxin and mycoplasma contamination thus can qualify the cell culture grade. The f-HICF serum free media was prepared, optimised, and tested with A549, HeLa, 3T3, Vero and C2C12 cell lines. Our results conclude that f-HICF is a potential alternative to FBS, in accordance with ethical concern; compliance with 3R's; lack of unintended antibody interactions; presence of macro and micronutrients; simple extraction; cost-effectiveness and availability.

Impact of media supplements FGF2, LIF and IGF1 on the genome activity of porcine embryos produced in vitro.

In this article, we focused on the impact of precisely chemically modified FLI maturation medium enriched with fibroblast growth factor 2 (FGF2), leukemia inhibitory factor (LIF), insulin-like growth factor 1 (IGF1), and polyvinyl alcohol (PVA) and its potential to improve the efficiency of in vitro production of porcine embryos. We hypothesized that enhancing the composition of the maturation medium could result in an elevated production of embryos in vitro and can affect EGA. FLI medium resulted in a significantly higher rate of oocyte blastocyst maturation and formation compared to the control DMEM medium. In addition, immunocytochemical labelling confirmed the detection of UBF in 4-cell FLI parthenogenic embryos, suggesting similarities with natural embryo development. Through RNAseq analysis, upregulated genes present in 4-cell FLI embryos were found to play key roles in important biological processes such as cell proliferation, cell differentiation, and transcriptional regulation. Based on our findings, we demonstrated the positive influence of FLI medium in the evaluation of in vitro embryo production, EGA detection, transcriptomic and proteomic profile, which was confirmed by the positive activation of the embryonal genome in the 4-cell stage of parthenogenetically activated embryos.

Strain-specific features of Pleurotus ostreatus growth in vitro and some of its biological activities.

BACKGROUND: The production of Pleurotus ostreatus mycelium as a promising object for use in food and other industries is hampered by a lack of information about the strain-specificity of this fungus mycelium growth and its acquisition of various biological activities. Therefore, this research aimed to investigate mycelial growth of different P. ostreatus strains on varies solid and liquid media as well as to evaluate strains antagonistic, antibacterial, antiradical scavenging activities, and total phenolic content. RESULTS: Potato Dextrose Agar medium was suitable for all strains except P. ostreatus strain 2460. The best growth rate of P. ostreatus 2462 strain on solid culture media was 15.0 ± 0.8 mm/day, and mycelia best growth on liquid culture media-36.5 ± 0.2 g/l. P. ostreatus strains 551 and 1685 were more susceptible to positive effect of plant growth regulators Ivin, Methyur and Kamethur. Using of nutrient media based on combination of natural waste (amaranth flour cake and wheat germ, wheat bran, broken vermicelli and crumbs) has been increased the yield of P. ostreatus strains mycelium by 2.2-2.9 times compared to the control. All used P. ostreatus strains displayed strong antagonistic activity in co-cultivation with Aspergillus niger, Candida albicans, Issatchenkia orientalis, Fusarium poae, Microdochium nivale in dual-culture assay. P. ostreatus 2462 EtOAc mycelial extract good inhibited growth of Escherichia coli (17.0 ± 0.9 mm) while P. ostreatus 2460 suppressed Staphylococcus aureus growth (21.5 ± 0.5 mm) by agar well diffusion method. The highest radical scavenging effect displayed both mycelial extracts (EtOH and EtOAc) of P. ostreatus 1685 (61 and 56%) by DPPH assay as well as high phenolic content (7.17 and 6.73 mg GAE/g) by the Folin-Ciocalteu's method. The maximal total phenol content (7.52 mg GAE/g) demonstrated of P. ostreatus 2461 EtOH extract. CONCLUSIONS: It is found that the growth, antibacterial, antiradical scavenging activity as well as total phenolic content were dependent on studied P. ostreatus strains in contrast to antagonistic activity. The proposed culture mediums of natural waste could be an alternative to commercial mediums for the production mycelial biomass of P. ostreatus strains.

Exploring metabolic effects of dipeptide feed media on CHO cell cultures by in silico model-guided flux analysis.

There is a growing interest in perfusion or continuous processes to achieve higher productivity of biopharmaceuticals in mammalian cell culture, specifically Chinese hamster ovary (CHO) cells, towards advanced biomanufacturing. These intensified bioprocesses highly require concentrated feed media in order to counteract their dilution effects. However, designing such condensed media formulation poses several challenges, particularly regarding the stability and solubility of specific amino acids. To address the difficulty and complexity in relevant media development, the biopharmaceutical industry has recently suggested forming dipeptides by combining one from problematic amino acids with selected pairs to compensate for limitations. In this study, we combined one of the lead amino acids, L-tyrosine, which is known for its poor solubility in water due to its aromatic ring and hydroxyl group, with glycine as the partner, thus forming glycyl-L-tyrosine (GY) dipeptide. Subsequently, we investigated the utilization of GY dipeptide during fed-batch cultures of IgG-producing CHO cells, by changing its concentrations (0.125 × , 0.25 × , 0.5 × , 1.0 × , and 2.0 ×). Multivariate statistical analysis of culture profiles was then conducted to identify and correlate the most significant nutrients with the production, followed by in silico model-guided analysis to systematically evaluate their effects on the culture performance, and elucidate metabolic states and cellular behaviors. As such, it allowed us to explain how the cells can more efficiently utilize GY dipeptide with respect to the balance of cofactor regeneration and energy distribution for the required biomass and protein synthesis. For example, our analysis results uncovered specific amino acids (Asn and Gln) and the 0.5 × GY dipeptide in the feed medium synergistically alleviated the metabolic bottleneck, resulting in enhanced IgG titer and productivity. In the validation experiments, we tested and observed that lower levels of Asn and Gln led to decreased secretion of toxic metabolites, enhanced longevity, and elevated specific cell growth and titer. KEY POINTS: • Explored the optimal Tyr dipeptide for the enhanced CHO cell culture performance • Systematically analyzed effects of dipeptide media by model-guided approach • Uncovered synergistic metabolic utilization of amino acids with dipeptide.

Effects of Melatonin, GM-CSF, IGF-1, and LIF in Culture Media on Embryonic Development: Potential Benefits of Individualization.

The implantation of good-quality embryos to the receptive endometrium is essential for successful live birth through in vitro fertilization (IVF). The higher the quality of embryos, the higher the live birth rate per cycle, and so efforts have been made to obtain as many high-quality embryos as possible after fertilization. In addition to an effective controlled ovarian stimulation process to obtain high-quality embryos, the composition of the embryo culture medium in direct contact with embryos in vitro is also important. During embryonic development, under the control of female sex hormones, the fallopian tubes and endometrium create a microenvironment that supplies the nutrients and substances necessary for embryos at each stage. During this process, the development of the embryo is finely regulated by signaling molecules, such as growth factors and cytokines secreted from the epithelial cells of the fallopian tube and uterine endometrium. The development of embryo culture media has continued since the first successful human birth through IVF in 1978. However, there are still limitations to mimicking a microenvironment similar to the reproductive organs of women suitable for embryo development in vitro. Efforts have been made to overcome the harsh in vitro culture environment and obtain high-quality embryos by adding various supplements, such as antioxidants and growth factors, to the embryo culture medium. Recently, there has been an increase in the number of studies on the effect of supplementation in different clinical situations such as old age, recurrent implantation failure (RIF), and unexplained infertility; in addition, anticipation of the potential benefits from individuation is rising. This article reviews the effects of representative supplements in culture media on embryo development.

Quantitative and qualitative analysis of cell culture media powders for mammalian cells by Raman microscopy.

Cell culture media are essential for large-scale recombinant protein production using mammalian cell cultures. The composition and quality of media significantly impact cell growth and product formation. Analyzing media poses challenges due to complex compositions and undisclosed exact compositions. Traditional methods like NMR and chromatography offer sensitivity but require time-consuming sample preparation and lack spatial information. Raman chemical mapping characterizes solids, but its use in cell culture media analysis is limited so far. We present a chemometric evaluation for Raman maps to qualify and quantify media components, evaluate powder homogeneity, and perform lot-to-lot comparisons. Three lots of a marketed cell culture media powder were measured with Raman mapping technique. Chemometrics techniques have outlined a strategy to extract information from complex data. First, a spectral library has been structured. In addition to the 23 spectra for presumed ingredients, we obtained another 9 pure components with Multivariate Curve Resolution-Alternating Least Squares (MCR-ALS). Then the Spectral Angle Mapper-Orthogonal Projection (SAM-OP) algorithm revealed whether references actually occur in the mapped media powders. Finally, a quantification was provided by Classical Least Squares (CLS) modelling. Quantities of 18 significant amino acids mostly correlated with the reference method. The proposed method can be generally applied even for such complicated samples. Leveraging Raman mapping and innovative chemometric methods enhance recombinant protein production by improving the understanding of the spatial distribution and composition of cell culture media in mammalian cell cultivations.

Buffer-free CAS assay using a diluted growth medium efficiently detects siderophore production and microbial growth.

Siderophores are iron chelators and low-molecular-weight compounds secreted by various microorganisms under low-iron conditions. Many microorganisms produce siderophores in the natural environment as iron is an essential element for many of them. CAS assays are widely used to detect siderophores in cultures of various microorganisms; however, it is necessary to improve their sensitivity for the efficient application to fastidious microorganisms. We developed a simple, high-throughput CAS assay employing a buffer-free CAS reagent and diluted growth medium (10% dR2A) in a 96-well microplate. Using a diluted growth medium in agar plates suitable for iron-restricted conditions supported siderophore production by microorganisms from activated sludge. A buffer-free CAS reagent combined with a diluted growth medium revealed that these microorganisms tended to produce more siderophores or iron chelators than microorganisms under iron-rich conditions. Moreover, this buffer-free CAS assay easily and efficiently detected not only siderophore production but also the growth of fastidious microorganisms.

Validation of the cell culture monitoring using a Raman spectroscopy calibration model developed with artificially mixed samples and investigation of model learning methods using initial batch data.

The development of calibration models using Raman spectra data has long been challenged owing to the substantial time and cost required for robust data acquisition. To reduce the number of experiments involving actual incubation, a calibration model development method was investigated by measuring artificially mixed samples. In this method, calibration datasets were prepared using spectra from artificially mixed samples with adjusted concentrations based on design of experiments. The precision of these calibration models was validated using the actual cell culture sample. The results showed that when the culture conditions were unchanged, the root mean square error of prediction (RMSEP) of glucose, lactate, and antibody concentrations was 0.34, 0.33, and 0.25 g/L, respectively. Even when variables such as cell line or culture media were changed, the RMSEPs of glucose, lactate, and antibody concentrations remained within acceptable limits, demonstrating the robustness of the calibration models with artificially mixed samples. To further improve accuracy, a model training method for small datasets was also investigated. The spectral pretreatment conditions were optimized using error heat maps based on the first batch of each cell culture condition and applied these settings to the second and third batches. The RMSEPs improved for glucose, lactate, and antibody concentration, with values of 0.44, 0.19, and 0.18 g/L under constant culture conditions, 0.37, 0.12, and 0.12 g/L for different cell lines, and 0.26, 0.40, and 0.12 g/L when the culture media was changed. These results indicated the efficacy of calibration modeling with artificially mixed samples for actual incubations under various conditions.

Mammalian embryo culture media: now and into the future.

For over 70years, since the culture of the first mammalian embryo in vitro , scientists have undertaken studies to devise and optimise media to support the manipulation and culture of gametes and embryos. This area of research became especially active in the late 1970s onwards following the successful birth of the first human in vitro fertilised embryo. This review summarises some of the key advances in mammalian embryo culture media over time based on a greater understanding of the biochemical milieu of the reproductive tract. It highlights how learnings from studies in mice and agricultural species have informed human culture media compositions, in particular the inclusion of albumin, growth factors, cytokines, and antioxidants into contemporary culture media formulations, and how these advances may then in turn help to inform and guide development of in vitro culture systems used in other arenas, in particular agriculture. Additionally, it will highlight how the introduction of new technologies, such as timelapse, can influence current trends in media composition and usage that may see a return to a single step medium.

Analysis of commercial fetal bovine serum (FBS) and its substitutes in the development of cultured meat.

Fetal bovine serum (FBS) is an extremely important culture growth supplement, accounting for approximately 60 % of cell-culture-media costs; therefore, lowering FBS-acquisition costs for the industrialization of cultured meat is imperative. This study attempted to produce an FBS substitute using discarded livestock by-products, with particular focus on formulating a product with a composition similar to that of FBS to improve effectiveness. However, to date, no study has precisely analyzed the commercial components of FBS, and this study is the first to compare the chemical composition of FBS and commercially available horse serum purchased from the United States or Europe with that of FBS substitutes developed by our team. This study analyzed the chemical composition of the FBS products purchased by our team over the past 3 years via blood, sodium dodecyl sulfate-polyacrylamide gel electrophoresis, and independent composition analyses. While the composition and quality of commercial FBS products are known to vary, the FBS composition of our purchased products was relatively uniform regardless of company, brand, or country of origin. In contrast, FBS substitutes obtained from three major livestock species (cattle, pig, and chicken) clearly exhibited differences in composition, a phenomenon that was also observed upon comparing with FBS as well as among different species. Therefore, to replace commercial FBS entirely, the production of a proportionately effective substitute product comprising an equal or similar composition is required, and the results of this study can be a steppingstone to achieving this. In addition, FBS substitutes manufactured using inexpensive slaughter by-products as raw materials are expected to ultimately reduce the unit cost of cultured meat production.

Impact of malt concentration in solid substrate on mycelial growth and network connectivity in Ganoderma species.

With its distinctive material properties, fungal mycelium has emerged as an innovative material with a diverse array of applications across various industries. This study focuses on how the growth strategies of wood fungi adapt to nutrient availability. The effect of malt extract concentration in the growth medium on radial growth kinetics, morphology, mycelium network connectivity, and mechanical characteristics of mycelium from two Ganoderma species were investigated. While an evident pattern of radial growth rate enhancement with malt concentrations was not apparent, there was a discernible trend towards denser mycelium network characteristics as revealed by spectrophotometry. Increased malt extract contents corresponded to elevated optical density measurements and were visually confirmed by denser mycelium networks in photographic images. Investigating the mechanical characteristics of mycelium cultivated on varying solid substrate concentrations, the Young's modulus exhibited a substantial difference between mycelium grown on 5 wt% malt substrate and samples cultivated on 2 wt% and 0.4 wt% malt substrates. The obtained results represent a new understanding of how malt availability influences mycelial growth of two Ganoderma species, a crucial insight for potentially refining mycelium cultivation across diverse applications, including meat alternatives, smart building materials, and alternative leather.

Hyaluronic acid production by Klebsiella pneumoniae strain H15 (OP354286) under different fermentation conditions.

BACKGROUND: Hyaluronic acid (HA) has gained significant attention due to its unique physical, chemical, and biological properties, making it widely used in various industries. This study aimed to screen bacterial isolates for HA production, characterize favorable fermentation conditions, and evaluate the inhibitory effect of bacterial HA on cancer cell lines. RESULTS: A total of 108 bacterial isolates from diverse sources were screened for HA production using HPLC, turbidimetric, and carbazole determination methods. Among the HA-producing isolates, Klebsiella pneumoniae H15 isolated from an animal feces sample, was superior in HA production. The strain was characterized based on its morphological, cultural, and biochemical characteristics. Molecular identification using 16S rDNA sequencing and phylogenetic analysis confirmed its identity. Fermentation conditions, including pH, temperature, time, and agitation rate, were optimized to maximize HA production. The basal medium, comprising sucrose (7.0%) as carbon source and combined yeast extract with peptone (1.25% each) as nitrogen substrate, favored the highest HA production at pH 8.0, for 30 h, at 30 °C, under shaking at 180 rpm. The average maximized HA concentration reached 1.5 g L-1. Furthermore, bacterial HA exhibited a significant inhibitory effect on three cancer cell lines (MCF-7, HepG-2 and HCT), with the lowest concentration ranging from 0.98-3.91 µg mL-1. CONCLUSIONS: K. pneumoniae H15, isolated from animal feces demonstrated promising potential for HA production. The most favorable fermentation conditions led to a high HA production. The inhibitory effect of bacterial HA on cancer cell lines highlights its potential therapeutic applications. These findings contribute to a broader understanding and utilization of HA in various industries and therapeutic applications.

Biological Characteristics of Beauveria majiangensis Strain MJ1015 and Optimization of Solid Medium Technology for Sporulation.

The entomopathogenic fungus Beauveria majiangensis strain MJ1015, recently isolated from white grubs on a blueberry farm in Guizhou, China, could be used as a biocontrol agent. As a first step toward determining the effect of different solid culture media, temperature, and pH on colony growth rate and sporulation, we evaluated the optimum solid medium for mycelial growth and conidia production on a commercial scale. Subsequently, we also used single-factor analysis and response surface optimization to optimize the composition of the solid culture medium. On potato dextrose agar (PDA) medium, MJ1015 grew fastest and produced the highest spore yield at 29°C and pH 5. The best solid medium for the growth and sporulation of strain MJ1015 comprised 64.70 g/l of rice, 13.00 g/l of wheat, 0.30 g/l of NaNO3, 0.36 g/l of K2HPO4 · 3H2O, and 1.00 g/l of CaCO3. Rice, NaNO3, and K2HPO4 · 3H2O were the main influencing factors. The predicted value of cultured spores using the optimal medium was 4.56 x 1010 conidia/l. The validation test results showed that the average growth rate of strain MJ1015 on the optimal medium was 85% and 96% faster than that on Sabouraud dextrose agar with yeast extracts medium (SDAY) and PDA, respectively. Sporulation was 43.90 times and 9.65 times of that produced on SDAY and PDA, respectively. Our findings provide a theoretical basis for the commercial production of B. majiangensis to control white grubs.

Trace impurities in sodium phosphate influences the physiological activity of Escherichia coli in M9 minimal medium.

In the field of applied microbiology, reproducibility and experimental variability are important factors that influence both basic research as well as process development for industrial applications. Experimental reproducibility and accuracy depend not only on culture conditions such as temperature and aeration but also on raw materials and procedures used for media preparation. The M9 minimal medium is one of the most common synthetic media for culturing Escherichia coli and other bacteria. This synthetic medium can be used to observe and evaluate the physiological activity of microbes under minimal nutritional requirements and determine the limiting factor for the desired phenotype. Although one of the advantages using the M9 medium is that its composition can be modulated, it is difficult to control presence of trace components and impurities from the reagents for preparing this medium. Herein, we showed that trace ingredients present in the reagents used for M9 media preparation affect the bacterial physiological activities (e.g., cell growth, substrate consumption, and byproduct formation). Additionally, we systematically identified the trace ingredient that influenced phenotypic differences. Our results showed that the selection of reagents and accuracy during reagent preparation is important for experimental reproducibility in the field of bio-engineering and systems biology focused on the systematic and continuous development of biomolecular systems (e.g., biorefinery, metabolic engineering, and synthetic biology).

Comparison of protein profiles obtained by matrix-assisted laser desorption/ionization-Time-of-flight mass spectrometry in representatives of the family Mycobacteriaceae grown on various nutrient media.

Background: The nutrient medium effects on the quality of the matrix-assisted laser desorption/ionization-time-of-flight (MALDI-ToF) mass spectra. The standard library includes spectra of microorganisms of the family Mycobacteriaceae grown on the Lowenstein-Jensen and Middlebrook Media. There are new methods for culturing microorganisms from this group, including inoculation on chromogenic media. Methods: The study included 240 strains of NTM isolated from patients during tuberculosis examination. The inoculation of the biological material was carried out on solid culture media of Lowenstein-Jensen and universal chromogenic media. Identification of bacteria from both types of media was performed by MALDI-ToF mass spectrometry (Bruker Daltonik GmbH, Germany). Analysis of protein spectra was performed. Results: For all strains, the spectra revealed both coinciding peaks (regardless of the cultivation medium) and significant differences, including the complete absence of some peaks depending on the medium. The results of a greater divergence of peaks in mass and intensity were obtained for slow-growing species than for fast-growing species. For all analyzed cultures, the number of peaks in the mass spectra was significantly higher when cultivating on a universal chromogenic medium than on a Lowenstein-Jensen medium. Conclusions: The use for NTM cultivation of a universal chromogenic medium makes it possible to obtain acceptable identification results by MALDI-ToF mass spectrometry using a standard library.

Debottlenecking and reformulating feed media for improved CHO cell growth and titer by data-driven and model-guided analyses.

Designing and selecting cell culture media along with their feeding are a key strategy to maximize culture performance in biopharmaceutical processes. However, the sensitivity of mammalian cells to their culture environment necessitates specific nutritional requirements for their growth and the production of high-quality proteins such as antibodies, depending on the cell lines and operational conditions employed. In this regard, previously we developed a data-driven and in-silico model-guided systematic framework to investigate the effect of growth media on Chinese hamster ovary (CHO) cell culture performance, allowing us to design and reformulate basal media. To expand our exploration for media development research, we evaluated two chemically defined feed media, A and B, using a monoclonal antibody-producing CHO-K1 cell line in ambr15 bioreactor runs. We observed a significant impact of the feed media on various aspects of cell culture, including growth, longevity, viability, productivity, and the production of toxic metabolites. Specifically, the concentrated feed A was inadequate in sustaining prolonged cell culture and achieving high titers when compared to feed B. Within our framework, we systematically investigated the major metabolic bottlenecks in the tricarboxylic acid cycle and relevant amino acid transferase reactions. This analysis identified target components that play a crucial role in alleviating bottlenecks and designing highly productive cell cultures, specifically the addition of glutamate to feed A and asparagine to feed B. Based on our findings, we reformulated the feeds by adjusting the amounts of the targeted amino acids and successfully validated the effectiveness of the strategy in promoting cell growth, life span, and/or titer.

Unraveling the potential and constraints associated with corn steep liquor as a nutrient source for industrial fermentations.

Costly complex media components such as yeast extract and peptone are still widely used in industrial bioprocesses, despite their ill-defined composition. Side stream products such as corn steep liquor (CSL) present a compelling economical alternative that contains valuable nutrients required for microbial growth, that is, nitrogen and amino acids, but also vitamins, trace elements, and other minerals. However, as a side stream product, CSL may be subject to batch-to-batch variations and compositional heterogeneity. In this study, the Respiration Activity MOnitoring System designed for shake flasks (RAMOS) and 96-well microtiter plates (µTOM) were applied to investigate the potential and constraints of CSL utilization for two model microorganisms: E. coli and B. subtilis. Considering the dry substance content of complex nutrients involved, CSL-based media are more efficient in biomass production than the common lysogeny broth (LB) medium, containing 5 g/L yeast extract, 10 g/L peptone, and 5 g/L NaCl. At a glucose to CSL (glucose/CSL, g/g) ratio of 1/1 (g/g) and 2/1 (g/g), a secondary substrate limitation occurred in E. coli and B. subtilis cultivations, respectively. The study sheds light on differences in the metabolic activity of the two applied model organisms between varying CSL batches, which relate to CSL origin and production process, as well as the effect of targeted nutrient supplementation. Through a targeted nutrient supplementation, the most limiting component of the CSL-glucose medium used for these applied model microorganisms was identified to be ammonium nitrogen. This study proves the suitability of CSL as an alternative nutrient source for E. coli and B. subtilis. The RAMOS and µTOM technique detected differences between CSL batches, allowing easy and early identification of varying batches. A consistent performance of the CSL batches in E. coli and B. subtilis cultivations was demonstrated.